Is the Chrysler Voyager more reliable than the Dodge Grand-Caravan?

Not by the overall comparison, though the gap is small. Both vans stand as good, but the Grand-Caravan averages 0.3 unscheduled shop visits a year against 0.4 for the Voyager. The Voyager does draw far fewer owner complaints per 10,000 sold, so the answer depends on what you weigh.

Which has more recalls, the Voyager or the Grand-Caravan?

The Voyager has more in total, with 20 recalls across seven model years. The Grand-Caravan has 10 across three model years. The Voyager's span of years is longer, so the totals are not a like-for-like measure. Check the specific van's VIN for open recalls before buying.

Which costs less to repair each year?

The Voyager, at $647 a year against $673 for the Grand-Caravan. That is $26 less annually, or roughly $130 over five years. The Grand-Caravan has fewer unscheduled shop visits, so the real-world difference in what you spend may be small.

What are the common transmission problems on the Grand-Caravan?

Owners describe shuddering, failure to shift, and holding one gear before the van lunges forward. Warning lights do not always appear. Failures cluster between about 59,500 and 91,715 miles and usually end in a full transmission replacement. Four power train complaints are linked to crashes.

Do Grand-Caravan sliding doors have a known problem?

Yes, in owner complaints. Latches seize and leave the door locked shut, often one side first and the other months later. Some doors will not lock and can open while moving. Mechanics blame worn latches or seized lock actuators, with repairs from over $600 to more than $1,300 per door.

Last updated: 2026-10-10

Chrysler Voyager vs Dodge Grand Caravan: Reliability Compared

Chrysler Voyager

Good

More Reliable

Dodge Grand Caravan

Good

Between the Chrysler Voyager and Dodge Grand-Caravan, the Grand-Caravan has a slight reliability edge because it needs fewer unscheduled shop visits. The Voyager costs a little less to maintain each year and draws far fewer owner complaints per van sold.

How Do the Chrysler Voyager and Dodge Grand Caravan Generations Compare?

Sixth-generation design covers every Voyager year, starting with the 2020 model year and refreshed for 2022. The 2023 to 2026 vans have had the least time to collect complaints, so a short record there says little. For the Grand-Caravan, the years covered here, 2018 to 2020, sit at the late end of a fifth generation that began in 2008 and was refreshed in 2011. A shopper looking at these vans is buying a design that had been on the road for a decade or more.

Verdict

The Dodge Grand Caravan is more reliable than the Chrysler Voyager, scoring 78/100 vs 75/100.

Reliability slightly favors the Dodge Grand-Caravan. It needs fewer unscheduled shop visits each year, 0.3 against 0.4 for the Voyager, and both vans stand as good. The edge is thin. The Voyager has far fewer owner complaints per vehicle sold and a lower yearly repair bill. The Grand-Caravan's complaint file is heavier, with transmission failures and stuck sliding doors. Its lead rests on how rarely it visits the shop, not on a cleaner record.

Key Differences

1Chrysler Voyager costs $26 less per year to repair
2Dodge Grand Caravan has 10 fewer total recalls
3Chrysler Voyager has 6.7 fewer complaints per 10k sold

Category Scoreboard

3Chrysler Voyager

—

3Dodge Grand Caravan

Reliability ScoreTotal RecallsComplaint RateAnnual Repair CostRepair FrequencySafety Rating

Chrysler Voyager vs Dodge Grand Caravan: Which Is More Reliable?

Chrysler Voyager vs Dodge Grand Caravan at-a-glance reliability comparison
Metric	Chrysler Voyager	Dodge Grand Caravan
Reliability Score	75/100	78/100
Years Tracked	7	3
Total Recalls	20	10
Complaints per 10k Sold	0.4	7.1
Annual Repair Cost	$647/yr	$673/yr
Repair Frequency	0.4/yr	0.3/yr
Safety RatingNHTSA overall	2026 NHTSA	2020 NHTSA
Frontal
Side
Rollover
Year Wins	0	1

What Are the Common Problems With the Chrysler Voyager and Dodge Grand Caravan?

Electrical and steering faults dominate the Voyager's complaints, while the Grand-Caravan's trouble is mechanical and more numerous. Voyager owners report the start/stop system failing, loss of acceleration at highway speed, batteries dying again within a year, and steering that sticks or cuts out mid-turn. Grand-Caravan owners describe transmissions that shudder or fail to shift, sliding door latches that seize, and a cylinder 2 misfire tied to low compression. Crash-linked reports appear only on the Grand-Caravan, in power train and seats. They include vans rolling away after being shifted into Park and head restraints bursting open.

Chrysler Voyager vs Dodge Grand Caravan common problem areas comparison
Component	Chrysler Voyager	Dodge Grand Caravan
ELECTRICAL SYSTEM	0.1Very Low	1.8Low
POWER TRAIN	—None	1Very Low
UNKNOWN OR OTHER	—None	1Very Low
STRUCTURE	—None	0.9Very Low
ENGINE	0.1Very Low	0.6Very Low
SEATS	—None	0.4Very Low
AIR BAGS	—None	0.3Very Low
STEERING	0.1Very Low	0.1Very Low
LATCHES/LOCKS/LINKAGES	—None	0.2Very Low
SERVICE BRAKES	—None	0.1Very Low
SEAT BELTS	—None	0.1Very Low

Complaints per 10,000 units sold, aggregated across all tracked model years from NHTSA owner reports.

Which Is Cheaper to Maintain: Chrysler Voyager or Dodge Grand Caravan?

Yearly repair cost favors the Voyager, at $647 against $673 for the Grand-Caravan, according to independent repair-cost data. That gap is $26 a year, or about $130 over five years. The Grand-Caravan makes up some ground by going to the shop less, at 0.3 unscheduled visits a year against 0.4. Its chance that a repair is major is 11%. No major-repair figure is given for the Voyager. Reported Grand-Caravan bills can be steep, from over $600 per door latch to over $5,000 for cylinder head work.

How Does Chrysler Voyager vs Dodge Grand Caravan Reliability Compare by Year?

Chrysler Voyager vs Dodge Grand Caravan year-by-year reliability scores
Year	Chrysler Voyager	Dodge Grand Caravan	Edge
2020	77/1001R / 10C	83/1001R / 15C	Dodge Grand Caravan

Best years to cross-shop: The 2020 Chrysler Voyager scored 77/100 and the 2020 Dodge Grand Caravan scored 83/100 — the strongest shared model years that have been on the road for at least two years, where available.

Who Should Buy the Chrysler Voyager vs the Dodge Grand Caravan?

Choose the Voyager if you want the lighter complaint record and the lower yearly repair cost. Within its run, 2020 has the best showing and has had time to collect complaints, while 2022 and 2023 are the weakest years. Newer years look clean mostly because they have had less time on the road. Before buying, test the steering on slow right turns and make sure the start/stop system and backup camera work. Choose the Grand-Caravan if you want the van that visits the shop least often. Target 2020, its strongest year. Avoid 2019, its weakest, and inspect any 2018 closely, since it appears among both the strongest and weakest years. Ask for transmission history, because failures cluster between about 59,500 and 91,715 miles. Test every sliding door, lock and unlock, and listen for a rough idle that could point to the cylinder 2 misfire. Ask whether the front head restraints have ever deployed.

Chrysler Voyager vs Dodge Grand Caravan: Common Questions

Is the Chrysler Voyager more reliable than the Dodge Grand-Caravan?: Not by the overall comparison, though the gap is small. Both vans stand as good, but the Grand-Caravan averages 0.3 unscheduled shop visits a year against 0.4 for the Voyager. The Voyager does draw far fewer owner complaints per 10,000 sold, so the answer depends on what you weigh.
Which has more recalls, the Voyager or the Grand-Caravan?: The Voyager has more in total, with 20 recalls across seven model years. The Grand-Caravan has 10 across three model years. The Voyager's span of years is longer, so the totals are not a like-for-like measure. Check the specific van's VIN for open recalls before buying.
Which costs less to repair each year?: The Voyager, at $647 a year against $673 for the Grand-Caravan. That is $26 less annually, or roughly $130 over five years. The Grand-Caravan has fewer unscheduled shop visits, so the real-world difference in what you spend may be small.
What are the common transmission problems on the Grand-Caravan?: Owners describe shuddering, failure to shift, and holding one gear before the van lunges forward. Warning lights do not always appear. Failures cluster between about 59,500 and 91,715 miles and usually end in a full transmission replacement. Four power train complaints are linked to crashes.
Do Grand-Caravan sliding doors have a known problem?: Yes, in owner complaints. Latches seize and leave the door locked shut, often one side first and the other months later. Some doors will not lock and can open while moving. Mechanics blame worn latches or seized lock actuators, with repairs from over $600 to more than $1,300 per door.

More Chrysler Voyager comparisons

Chrysler Voyager vs Kia Carnival reliability Chrysler Voyager vs Chrysler Pacifica reliability Chrysler Voyager vs Ford Transit Connect Wagon reliability Chrysler Voyager vs Mercedes-Benz Metris Passenger Van reliability Chrysler Voyager reliability by year Chrysler Voyager years to avoid

More Dodge Grand Caravan comparisons

Dodge Grand Caravan vs Chrysler Pacifica reliability Dodge Grand Caravan vs Ford Transit Connect Wagon reliability Dodge Grand Caravan vs Kia Carnival reliability Dodge Grand Caravan vs Mercedes-Benz Metris Passenger Van reliability Dodge Grand Caravan reliability by year Dodge Grand Caravan years to avoid

Decided between Chrysler Voyager and Dodge Grand Caravan? Run a VIN check before you buy — uncover hidden accidents, title issues, and open recalls.

Look Up a VIN →

How we score the Chrysler Voyager and Dodge Grand Caravan

Scores weight complaint severity at 35%, repair costs at 30%, recall impact at 20%, and the spread of complaints across systems at 15%, with complaint counts adjusted for US sales. Read the full methodology.

See incorrect data? Report an issue